Troubleshooting Tire Wear Down Middle of Tread on Trailer
Question:
I have a Harbor Freight Haul Master folding trailer rated for 1195 lbs. I use it to carry a kayak and fishing gear. The kayak + gear probably weighs only 150 lbs. I never travel more than 55 mph with the trailer. I probably travel about 750-1000 miles per season. The trailer uses 4.80-12 tires. The original HF tires Kenda? were inflated to the recommended max embossed on the rubber sidewall but these wore out within the first season, showing a distinct wear pattern down the middle of the tire. So I replaced with Carlisle Sport Trail tires and lowered the pressure down to 25 PSI. I noticed that they were still wearing down in the middle of the tread with little to no wear at the edges, so I dropped pressure to 16 PSI. They still continued to wear down the center! I removed 2 leaves from the spring pack to get a smoother ride for my kayak and now need to replace the tires again. 1. What load rating should I be looking for when buying tires for this trailer and relatively lightweight application? Is there any downside to getting a tire rated for a heavier load than I need? 2. If tires continue to show wear down the middle instead of evenly across the surface, should I keep lowering pressure? I understand that it is dangerous to travel at high speed with underinflated tires, but what is underinflatedinch with such a light load? 3. What tires do you recommend?
asked by: Jim F
Helpful Expert Reply:
Generally speaking, a trailer tire will wear in the middle of the tread when it is over-inflated, however that does not appear to be the case with the tires on your trailer. With that being said, I do not recommend lowering the pressure on the tires to below the maximum psi recommended on the sidewall. Doing this will essentially lower the tire's load capacity to an unknown number, which may lead to you overloading them and causing further damage to the tires and trailer. A trailer tire should always be inflated to its recommended maximum psi.
I also don't recommend removing leafs from the spring stack on the trailer, as this will also result in lowering the trailer's capacity to an unknown number. The spring stack's weight rating is tested with all the leafs in place, so removing any number of them will lower it.
I spoke with our resident tire expert regarding the wear issues you are having. Since you are still experiencing the same problems with the tire pressures lowered, most likely the underlying cause is something in the trailer's suspension and not on the tire itself. Something may be broken, loose or damaged and it is causing the tire to have irregular wear. I recommend checking the suspension thoroughly to see if there are any issues. Otherwise you can take the trailer to a local trailer shop to see if they can inspect everything to make sure it is in good working order.
Lastly, when choosing the load rating for a tire, you will just need to make sure that the combined capacity of all the tires meets or exceeds the loaded weight of the trailer. There is no harm in going with an over-rated tire. I have attached a link that will take you to our available selection of 4.80-12 trailer tires along with an article that you might find helpful.
Product Page this Question was Asked From
Loadstar 4.80-12 Bias Trailer Tire with 12" Galvanized Wheel - 5 on 4-1/2 - Load Range C
- Trailer Tires and Wheels
- Tire with Wheel
- Bias Ply Tire
- Load Range C
- 4.80-12
- 12 Inch
- 5 on 4-1/2 Inch
- Steel Wheels - Galvanized
- Kenda
more information >
Featured Help Information
Miscellaneous Media
Continue Researching
- Shop: Loadstar 4.80-12 Bias Trailer Tire with 12" Galvanized Wheel - 5 on 4-1/2 - Load Range C
- Shop: Kenda K353 Bias Trailer Tire - 5.30-12 - Load Range D
- Q&A: Recommendation for Upgrading to Larger Tires from 5.30-12 Tires on Trailer
- Q&A: Which is Better for Highway Use 4.80-12 or 5.30-12 Trailer TIres
- Q&A: Upgrading 4.80-12 Tires On Yacht Club Trailer
- Shop: Dielectric Grease for Electrical Connectors, 2 oz.
- Shop: Kenda Karrier S-Trail ST145/R12 Radial Trailer Tire - Load Range D
- Search Results: trailer coupler locks
- Q&A: Highest Speed Rating for a 4.80 x 12 Trailer Tire
- Shop: etrailer Hitch Pin Alignment Collar for Hitch Accessories - 2" Hitches
- Q&A: Max Highway Speed Rating for 4.80-12 Tires
- Shop: Greystone Electric RV Fireplace with Crystals - 26" Wide - Recessed Mount - Black
- Q&A: How to Select Trailer Tires with Correct Load Range Rating for Trailer Gross Weight
- Shop: Gooseneck Hitch
- Video: Ultra-Fab Motorcycle Carrier with Ramp Test Course
- Video: Comprehensive Review: Ultra-Fab Dirt Bike Carrier for 2" Hitches
- Q&A: Lug Nut Torque for a Trailer Wheel
- Search Results: motorcycle carrier hitch cargo carrier
- Search Results: double hitch
- Search Results: wheel chocks
- Shop: Ultra-Fab Dirt Bike Carrier for 2" Hitches - With Ramp - 77" Long - 500 lbs
- Search Results: 48 x 12 tire
- Search Results: 48 x12
- Search Results: st145r12
- Shop: Trailer Hitch
- Shop: Trailer Wiring
- Video: Mount: T-One Vehicle Wiring Harness with 4-Pole Flat Trailer Connector on a 2018 Chrysler Pacifica
- Video: 2018 Chrysler Pacifica Draw-Tite Max-Frame Trailer Hitch Receiver: Complete Installation
- Video: Install: Draw-Tite Max-Frame Trailer Hitch Receiver on a 2021 Chrysler Pacifica
- Video: Comprehensive Review: T-One Vehicle Wiring Harness with 4-Pole Flat Trailer Connector-118712
on Trailer Tires and Wheels
